U.S. renewable diesel production and biodiesel production declined in 1Q 2025
U.S. production of renewable diesel and biodiesel fell sharply in the first quarter of 2025 (1Q25) because of uncertainty related to federal biofuel tax credits and negative profit margins. The EIA forecast production of both fuels to increase as the year progresses but biodiesel production to remain less than in 2024.
Renewable diesel and biodiesel are biomass-based diesel fuels that can replace petroleum-based distillate and be used to comply with renewable volume obligations in the Renewable Fuel Standard (RFS) administered by the U.S. Environmental Protection Agency (EPA). Renewable diesel can be used in diesel engines in any concentration because it is chemically equivalent to petroleum-based distillate fuel, and biodiesel is typically blended with petroleum distillate at concentrations of 20% or less for vehicle consumption because of some chemical differences.
In January 2025, U.S. production of biodiesel fell to 60,000 barrels per day (b/d), the least since January 2015, and about 40% less than in January 2024. U.S. biodiesel producers only partially ramped up production in February and March, bringing the quarterly production to about 70,000 b/d, a decrease of more than 30% from 1Q24.
U.S. renewable diesel production averaged about 170,000 b/d in 1Q25, down 12% from 1Q24. The decrease in renewable diesel production was not as large on a percentage basis as the decrease in biodiesel production, mostly because renewable diesel production increased at a greater rate than biodiesel production in 2024. Reduced output at renewable diesel plants was partially offset by the nearly 20% increase in renewable diesel production capacity since 1Q24. However, compared with 4Q24, when renewable diesel production capacity was comparable to current levels, 1Q25 production was down almost 25%.
Poor profitability in 1Q25 contributed to production declines. Diamond Green Diesel, Phillips 66 and Marathon all reported operating losses from renewable diesel in the quarter. In addition, trade press has suggested negative margins for biodiesel.
Another reason U.S. production of biomass-based diesels declined in 1Q25 was uncertainty about federal biofuel tax credits. Before 2025, producers and importers of biomass-based diesel received a $1 per gallon (gal) blender’s tax credit (BTC) for each gallon blended with petroleum diesel. Under the Inflation Reduction Act, the BTC was slated to be replaced with the Section 45Z Clean Fuels Production Credit in 2025. This new credit would change the flat $1/gal tax credit to a value based on the carbon intensity of the feedstocks used. However, delays in releasing final guidance for the tax credit has left biofuel producers unsure about their profitability, causing some producers to idle operations.
The EIA forecast production of renewable diesel and biodiesel to increase as the year progresses to meet existing RFS mandates. In the EIA’s May Short-Term Energy Outlook, the organization forecasted 2025 annual renewable diesel production to increase about 5% from 2024 because of increased capacity. The EIA forecast 2025 annual biodiesel production to be 15% lower than in 2024 because of low production early in the year and an assumption that some biodiesel plants with less favorable economics may close.
Comments